Water Heater Pilot Tube Leaking

A layer of dirt and grime can hinder the electric current from reaching the thermocouple.

Water heater pilot tube leaking.

To reattach the three lines to the gas valve thread the nuts into place with your fingers and hand tighten them. It acts as a safety device to prevent gas leaks. If this is a gate style valve a wheel that turns turn the valve clockwise as far as you can. Below is a list of the four most probable causes of a leak in your water heater.

Then snug them up with a quarter to half revolution with a wrench. The most likely scenario in this case is that sediment has built up and corroded the bottom of the tank causing a serious problem and the need for an entirely new water heater. Turn off the water. As best as i can tell the water is leaking through the pilot tube.

Water is leaking from my hot water heater in the attic into the bathroom below. What to do with a leaking water heater step 1. The other is the thermocouple tube. At first before i knew the name of the pilot tube i figured it was to feed water to the temperature control system to regulate water temperature.

Although these are the two most common causes of a leaking water heater they are not always the culprits. When relit the water heater pilot light flame should wrap around the thermocouple bulb. Disconnect the bracket holding both tubes to the gas valve using a. Flexible water supply tubes are the most common cause of leaks above the water heater since it is common for these tubes to fail long before the water heater is ready for replacement.

Gas leak from pilot tube unicuk. You can use a mixture of water and dish soap to discover where it is leaking. The thermocouple is triggered by an electric current produced by the pilot light. Combine in a container and gently swish around until it is evenly distributed.

Therefore a dirty thermocouple might be the reason why your water pilot keeps going out. I m not sure of the ratio but you want it the consistency to be somewhat thicker than water maybe 1 cup water and one table spoon dish soap. How to light a gas water heater pilot light duration. Your water heater tank should have a dedicated shutoff valve on the cold inlet pipes.

Locate the pilot tube. If you experience a leaking water heater it is recommended to turn off the water to your tank. If there is insulation around the supply tubes remove it so you can inspect and replace the tubes if necessary.